Cold Air Return Vent

A forced-air system is one which uses air as its heat transfer medium. These systems relies on ductwork, vents, and plenums as a means of air distribution separate from the actual Heating and Air Conditioning systems. The return plenum carries the air from several large return grills (vents) to a central air handler for re-heating. The supply plenum directs air from the central unit to the rooms which the system is designed to heat. Regardless of type, all air handlers consist of an air filter, blower, heat exchanger/element/coil, and various controls. Like any other kind of central heating system, thermostats are used to control forced air heating systems.

Forced air heating is probably the type most commonly installed in North America. It is less common in Europe, particularly in the United Kingdom (where it is typically referred to as "warm air" heating).

Types

Natural gas/propane/oil

• Heat is produced via combustion of fuel
• A heat exchanger keeps the combustion byproducts from entering the air stream
• A ribbon style (long with holes), inshot (torch-like), or oil type burner is located in the heat exchanger
• Ignition is provided by an electric spark, standing pilot, or hot surface igniter
• Safety devices ensure that combustion gases and/or unburned fuel do not accumulate in the event of an ignition failure or venting problem

Electric

• A simple electric heating element warms the air
• When the thermostat call for heat, blower and element come on at the same time
• When thermostat is "satisfied", blower and element shut off
• Requires very little maintenance
• Used to be very expensive to operate, but newer high efficiency units combined with the extreme cost of natural gas have made the electric heat system equally priced if not cheaper to operate than a natural gas furnace.
• Safer operation. A home with an electric furnace does not have to worry about being poisoned by carbon dioxide or the possibility of a natural gas leak into the home which could cause an explosion.
• Very quiet operation
• Does not produce emissions, often the choice for a "green home".
• Many cities or states offer incentive programs to home owners who install electric furnaces, in an attempt to reduce fugitive emissions. Many utility companies also will have a secondary, cheaper electricity rate offered to those who run their home with electric heat. A separate meter must be installed and hooked to the heater, this will cost the consumer at first, but the discount will pay itself off in less than a year.
• However, electric rates vary greatly across the US, so it is important to do research on local KWH prices with different utilities.

Heat Pump

• Extracts heat from outdoor air via the refrigeration cycle
• More efficient than fossil fuel fired furnaces (gas/oil) and electric resistance heating
• Not suitable for cold climates unless used with backup (secondary) source of heat. Newer air/air heatpumps can provide heat well below 0 degrees Celsius (32 °F).
• A refrigerant coil is located in the air handler instead of a heat exchanger or element. System can also be used in cooling, just as any central air-conditioning system.
• See Heat pumps

Hydronic coil

• Combines hydronic (hot water) heating with a forced air delivery
• Heat is produced via combustion of fuel (gas/propane/oil) in a boiler
• A heat exchanger (hydronic coil) is placed in the air handler similar to the refrigerant coil in a Heat Pump system or a Central AC
• Heated water is pumped through the heat exchanger then back to the boiler to be reheated

Sequence of operation

1. Thermostat calls for heat
2. Source of ignition is provided at the boiler
3. Circulator initiates water flow to the hydronic coil (heat exchanger)
4. Once the heat exchanger warms up, the main blower is activated
5. When call for heat ceases, the boiler and circulator turn off
6. Blower shuts off after period of time (depending on the particular equipment involved this may be a fixed or programmable amount of time)

Advantages and disadvantages of forced air systems

Advantages

• Can accommodate central air conditioning, humidifiers, HRVs, and whole-house air cleaners
• Excellent for programmable thermostats - takes a short time to recover
• Less expensive than hydronic systems
• No risk of structural damage due to water leaks
• Heatpumps and 90%+ AFUE (Annual Fuel Utilization Efficiency) systems are energy efficient
• High efficiency furnaces are more readily available than high efficiency boilers

Floor Registers, Return Air Grilles & Cold Air Returns

Shop our online store for decorative floor registers and cold air return grilles. We stock decorative, wood, metal return air grills and registers which will provide the finishing ...

...

Pattern Cut | Laser cuts decorative wood panels for air conditioner ...

Wood Vent Grilles; Return Air Filters; Flex Molding; Flex Crown; Ornament; Corbel ... Metal air conditioning grilles take away from the looks of your home. Our wood ...

...

cold air return vents, cold air vents, return air vents

A professional manufacturer and supplier of cold air return vents, cold air vents, return air vents

...

Walnut Cold Air Returns, Wall Mount Vent.

Wood vents that match your hardwood flooring. Many different colours to choose from. Stylish and aesthetically pleasing to the eye.

...

Cold Air Return vent - Topic Powered by Eve Community

Newsletter Signup: Subscribe to HGTVProFile for timely information on new products, best practices, professional advice and more. Subscribe Now!

...

Homewood Products - Cold Air Return: Grid

Cold Air Return: Grid. If you want to remember this vent for requesting information from Homewood, please check the attributes you'd like and ...

...

Heat Registers, Air Returns, and Vent Covers at Shop 4 Classics

Beautify your home with classic grilles for cold air returns or vintage-inspired heat registers ... Metal Vent Covers

...

Homewood Products - Cold Air Return: Single Direction, Self-Rimmed ...

Cold Air Return: Single Direction, Self-Rimmed, Beveled. If you want to remember this vent for requesting information from Homewood, please check the attributes ...

...

Maple Cold Air Returns, Wall Mount Vent.

Wood vents that match your hardwood flooring. Many different colours to choose from. Stylish and aesthetically pleasing to the eye.

...

Cold Air Return Vent Covers at Shop 4 Classics

Decorative cold air return vent covers and heat registers are a great way to extend the vintage them

...