A hybrid electric vehicle (HEV) combines a conventional internal combustion engine (ICE) propulsion system with an electric propulsion system. The presence of the electric powertrain is intended to achieve either better fuel economy than a conventional vehicle, or better performance. A variety of types of HEV exist, and the degree to which they function as EVs varies as well. The most common form of HEV is the hybrid electric car, although hybrid electric trucks (pickups and tractors) also exist.
Modern HEVs make use of efficiency-improving technologies such as regenerative braking, which converts the vehicle's kinetic energy into battery-replenishing electric energy, rather than wasting it as heat energy as conventional brakes do. Some varieties of HEVs use their internal combustion engine to generate electricity by spinning an electrical generator (this combination is known as a motor-generator), to either recharge their batteries or to directly power the electric drive motors. Many HEVs reduce idle emissions by shutting down the ICE at idle and restarting it when needed; this is known as a start-stop system. A hybrid-electric produces less emissions from its ICE than a comparably-sized gasoline car, as an HEV's gasoline engine is usually smaller than a pure fossil-fuel vehicle, and if not used to directly drive the car, can be geared to run at maximum efficiency, further improving fuel economy.
The hybrid-electric vehicle did not become widely available until the release of the Toyota Prius in Japan in 1997, followed by the Honda Insight in 1999. While initially perceived as unnecessary due to the low cost of gasoline, worldwide increases in the price of petroleum caused many automakers to release hybrids in the late 2000s; they are now perceived as a core segment of the automotive market of the future. Worldwide sales of hybrid vehicles produced by Toyota reached 1.0 million vehicles by May 31, 2007, and the 2.0 million mark was reached by August 31, 2009, with hybrids sold in 50 countries. Worldwide sales are led by the Prius, with cumulative sales of 1.43 million by August 2009. The second-generation Honda Insight was the top-selling vehicle in Japan in April 2009, marking the first occasion that an HEV has received the distinction. American automakers have made development of hybrid cars a top priority.
History
Further information: History of plug-in hybridsIn 1901, while employed at Lohner Coach Factory, Ferdinand Porsche designed the Mixte , a 4WD series-hybrid version of " System Lohner-Porsche " electric carriage previously appeared in 1900 Paris Salon. The Mixte included a pair of generators driven by 2.5-hp Daimler IC engines to extend operating range. The Mixte broke several Austrian speed records, and also won the Exelberg Rally in 1901 with Porsche himself driving. The Mixte used a gasoline engine powering a generator, which in turn powered electric hub motors, with a small battery pack for reliability. It had a range of 50 km, a top speed of 50 km/h and a power of 5.22 kW during 20 minutes.
In 1905, H. Piper filed a US patent application for a hybrid vehicle.
The 1915 Dual Power , made by the Woods Motor Vehicle electric car maker, had a four-cylinder ICE and an electric motor. Below 15 mph (25 km/h) the electric motor alone drove the vehicle, drawing power from a battery pack, and above this speed the "main" engine cut in to take the car up to its 35 mph (55 km/h) top speed. About 600 were made up to 1918.
The first gasoline-electric hybrid car was released by the Woods Motor Vehicle Company of Chicago in 1917. The hybrid was a commercial failure, proving to be too slow for its price, and too difficult to service.
In 1931 Erich Gaichen invented and drove from Altenburg to Berlin a 1/2 horsepower electric car containing features later incorporated into hybrid cars. Its maximum speed was 25 miles per hour (40 km/h), but it was licensed by the Motor Transport Office, taxed by the German Revenue Department and patented by the German Reichs-Patent Amt. The car battery was re-charged by the motor when the car went downhill. Additional power to charge the battery was provided by a cylinder of compressed air which was re-charged by small air pumps activated by vibrations of the chassis and the brakes and by igniting oxyhydrogen gas. An account of the car and his characterization as a "crank inventor" can be found in Arthur Koestler's autobiography, Arrow in the Blue, pages 269-271, which summarize a contemporaneous newspaper account written by Koestler. No production beyond the prototype was reported.
Predecessors of current technology
A more recent working prototype of the HEV was built by Victor Wouk (one of the scientists involved with the Henney Kilowatt, the first transistor-based electric car). Wouk's work with HEVs in the 1960s and 1970s earned him the title as the "Godfather of the Hybrid". Wouk installed a prototype hybrid drivetrain (with a 16 kilowatts (21 hp) electric motor) into a 1972 Buick Skylark provided by GM for the 1970 Federal Clean Car Incentive Program, but the program was stopped by the United States Environmental Protection Agency (EPA) in 1976 while Eric Stork, the head of the EPA at the time, was accused of a prejudicial coverup.
The regenerative braking system, the core design concept of most production HEVs, was developed by electrical engineer David Arthurs around 1978, using off-the shelf components and an Opel GT. However the voltage controller to link the batteries, motor (a jet-engine starter motor), and DC generator was Arthurs'. The vehicle exhibited 75 miles per US gallon (3.1 L/100 km; 90 mpg ) fuel efficiency, and plans for it (as well as somewhat updated versions) are still available through the Mother Earth News web site. The Mother Earth News' own 1980 version claimed nearly 84 miles per US gallon (2.8 L/100 km; 101 mpg ).
In 1989, Audi produced its first iteration of the Audi Duo (the Audi C3 100 Avant Duo) experimental vehicle, a plug-in parallel hybrid based on the Audi 100 Avant quattro. This car had a 9.4 kilowatts (12.8 PS; 12.6 bhp) Siemens electric motor which drove the rear roadwheels. A trunk-mounted nickel-cadmium battery supplied energy to the motor that drove the rear wheels. The vehicle's front roadwheels were powered by a 2.3 litre five-cylinder petrol engine with an output of 100 kilowatts (136 PS; 134 bhp). The intent was to produce a vehicle which could operate on the engine in the country, and electric mode in the city. Mode of operation could be selected by the driver. Just ten vehicles are believed to have been made; one drawback was that due to the extra weight of the electric drive, the vehicles were less efficient when running on their engines alone than standard Audi 100s with the same engine.
Two years later, Audi, unveiled the second duo generation, the Audi 100 Duo - likewise based on the Audi 100 Avant quattro. Once again, this featured an electric motor, a 21.3 kilowatts (29.0 PS; 28.6 bhp) three-phase machine, driving the rear roadwheels. This time, however, the rear wheels were additionally powered via the Torsen centre differential from the main engine compartment, which housed a 2.0 litre four-cylinder engine.
See also: Audi hybrid vehiclesThe Bill Clinton administration initiated the Partnership for a New Generation of Vehicles (PNGV) program on 29 September 1993, that involved Chrysler, Ford, General Motors, USCAR, the DoE, and other various governmental agencies to engineer the next efficient and clean vehicle. The United States National Research Council (USNRC) cited automakers' moves to produce HEVs as evidence that technologies developed under PNGV were being rapidly adopted on production lines, as called for under Goal 2. Based on information received from automakers, NRC reviewers questioned whether the "Big Three" would be able to move from the concept phase to cost effective, pre-production prototype vehicles by 2004, as set out in Goal 3. The program was replaced by the hydrogen-focused FreedomCAR initiative by the George W. Bush administration in 2001, an initiative to fund research too risky for the private sector to engage in, with the long-term goal of developing effectively carbon emission- and petroleum-free vehicles.
Production HEVs
See also: List of hybrid vehicles...
New Hybrid Cars | All New 2010 2009 Hybrid Car Models at Automotive ...
A hybrid car is a vehicle that uses a rechargeable ... cars are low-polluting and consume less gasoline than cars with pure internal combustion engines. The major difference between...
Vinod Khosla: Hybrid-electric cars won’t make a difference ...
Vinod Khosla: Hybrid-electric cars won’t make a difference ... process of making hybrid-electric cars, or cars that run only partially on gasoline. ... using wind for between one ...
What is the main difference between gasoline powered and electric ...
What is the main difference between gasoline powered and electric hybrid cars?
Difference between Fuel Cells and Hybrid Cars? | Hybrid Car Gurus
Difference between Fuel Cells and Hybrid Cars? ... natural gas, and the process releases as much CO2 as burning gasoline. ...
What’s the difference between summer-blend gasoline and winter-blend ...
The difference between conventional summer- and winter-blend gasoline has to do with the Reid Vapor Pressure of the ... Green/Hybrid Cars; How Does That Work? How Safe is This Car? I'm ...
Costs Of New Hybrid Cars Vs. Standard Gasoline Autos - carsdirect.com
Costs Of New Hybrid Cars Vs. Standard Gasoline Autos ... The price difference of hybrids is expected to ... However, the comparison between hybrid cars and gas autos ...
Difference between Fuel Cells and Hybrid Cars? - Yahoo! Answers
Difference between Fuel Cells and Hybrid Cars? ... natural gas, and the process releases as much CO2 as burning gasoline. ...
What is the Difference Between Electric Cars and Hybrid Cars?
What is the Difference Between Electric Cars and Hybrid Cars? ... or is driving at sustained high speeds, the gasoline engine kicks in. A hybrid car is a ...
What is the difference between diesel fuel and regular gasoline? - Ask ...
What is the difference between diesel fuel and regular gasoline? I suppose diesel is a good thing if newer ... who need it for their big rigs and focus on gasoline hybrid cars. The ...